Sony Str De315 415 Sm

STR-DE315/DE415 SERVICE MANUAL

A E P Model U K Model

P hoto : S T R -D E 415 model

Manufactured under license from Dolby Laboratories Licensing C orporation. “D O LB Y ”, “P R O LO G IC ” and the double-D symbol are trademarks of D olby Laboratories Licensing C orporation.

SPECIFICATIONS Amplifier section Power output Stereo mode

Surround mode

Frequency response

(DIN 1kHz, 4ohms) STR-DE415 : 80W + 80W STR-DE315 : 80W + 80W (DIN 1kHz, 4ohms) Front : STR-DE415 : 70W/ch STR-DE315 : 60W/ch Center : STR-DE415 : 70W STR-DE315 : 60W (only in PROLOG MODE) Rear : STR-DE415 : (DIN 1kHz, 4ohms) 70W STR-DE315 : (DIN 1kHz, 4ohms) 60W PHOTO : RIAA equalization curve ± 0.5dB TV/LD, CD, TAPE/MD, VIDEO : 10Hz - 50kHz ± 1dB

Inputs

PHONO (MM) CD, TAPE/MD, TV/LD, VIDEO

Sensitivity Impedance S/N (Weighting network, input level) 2.5mV 50 74dB Kilohms 72dB*** (A,2.5mV) 200mV 50 82dB Kilohms 82dB*** (A, 150mV) 150mV

BASS BOOST

+ 10dB at 70Hz

TONE

± 8dB at 100Hz and 10kHz

FM tuner section Tuning range

87.5 - 108.0MHz (OTHER) 65.0 - 74.0MHz (East European)

Aerial range

75ohms, unbalanced

Sensitivity

Mono : 18.3 dBf, 2.2µV /75ohms Stereo : 38.3 dBf, 22.5µV /75ohms

Usable sencitivity

11.2 dBf, 1µV /75ohms (IHF)

S/N

Mono : 76dB Stereo : 70dB

Harmonic diatortion at 1kHz

Mono : 0.3% Stereo : 0.5%

Separation

45dB at 1kHz

***78 IHF Output

Muting

TAPE/MD REC OUT : Voltage : 150mV, Impedance : 10 kilohms VIDEO AUDIO OUT : Voltage : 150mV, Impedance : 10 kilohms MIX AUDIO OUT (STR-DE415 only) Voltage : 2V Impedance : 10 kilohms PHONES :Accepts low and high impedance headphones Full mute

Frequency response

+ 0.5

30Hz - 15kHz – 2 dB — C ontinued on next page —

FM STEREO/FM-AM RECEIVER MIC R O F ILM

TABLE OF CONTENTS Selecitivity

60dB at 400kHz

Specifications ··············································································· 1

AM tuner section Tuning range

522 - 1611 kHz

1.

GENERAL

Aerial

Loop aerial

Location and Function of controls ················································ 3

Usable sensitivity

50dB/m (at 999kHz)

2.

EXPLANATION OF IC TERMINALS ··················· 5

S/N

54dB (at 50mV/m)

3.

DIAGRAMS

Harmonic distortion

0.5% (50mV/m, 400Hz)

Selectivity

35dB

3-1. 3-2. 3-3. 3-4. 3-5.

Circuit Boards Location ····················································· 6 Printed Wiring Boards — Main Section — ························ 7 Schematic Diagram — Main Section — ·························· 11 Schematic Diagram — Display Section — ······················ 16 Printed Wiring Boards — Display Section — ·················· 19

4.

EXPLODED VIEWS

General system

Tuner section : PLL quartz-locked digital synthesizer system Preamplifier section : Low-noise NF type equalizer Power amplifier section : Pure-complimentary SEPP

Power requirements

230VAC, 50/60Hz

Power consumption

STR-DE415 : 175W STR-DE315 : 175W

AC outputs

Switched 100W (except for the U.K. model)

Dimensions

430 × 145 × 295mm

4-1. Front Panel Section ·························································· 23 4-2. Chassis Section ································································· 24

5.

Mass (Approx.) 6.4kg Supplied accessories

FM wire aerial (1) AM loop aerial (1) Remote controller (remote) (1) Size AA (R6) batteries (2) Scart adaptor (1)

Design and specifications are subject to change without notice.

SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

—2—

ELECTRICAL PARTS LIST ································ 25

SECTION 1 GENERAL LOCATION AND FUNCTION OF CONTROLS 1

2 3

5

SECTION 2 EXPLANATION OF IC TERMINALS • IC201 µPD78044FGF-064-3B9

4

6

@º !• !§ !¢ @∞

@¢

@£

@™

SECTION 3 DIAGRAMS

@¡ !ª !¶ !∞

!£ !™ !¡!º 9 8 7

!¢ TA P E /MD button !∞ P H O N O button !§ T V /LD button !¶ T U N E R button !• V ID E O button !ª C D button @º D IR E C T button @¡ S H IF T button @™ N umeric buttons @£ Tuner control buttons @¢ P H O N E S jack @∞ S P E A K E R S (A /B ) buttons

1 P O W E R switch 2 C E N T E R LE V E L +, – buttons 3 R E A R LE V E L +, – buttons 4 S TA N D B Y indicator 5 F U N C T IO N indicators 6 MA S T E R V O LU ME control 7 B A LA N C E control 8 T R E B LE control 9 B A S S control !º B A S S B O O S T button/indicator !¡ S U R R O U N D O N /O F F button !™ MO D E button !£ E F F E C T /D E LAY T IME , S E T U P buttons

1

2

3-1.

Pin No.

Pin Name

I/O

1

DIG7

O

2

DIG6

O

3

DIG5

O

4

DIG4

O

5

DIG3

6

DIG2

7

DIG1

O

8

+5V

—

9

S. CLK

10

S. DATA

Description

Pin No.

Pin Name

I/O

41

VOLUME UP

O

Volume up.

42

VOLUME DOWN

O

Volume down.

43

STANDBY

O

Standby LED drive.

44

SYS. POWER

I

System power ON/OFF.

O

45

RDS. DATA. IN

I

RDS data input.

O

46

RDS. CLK. IN

I

RDS clock input. Stop signal input from NJM2103D (IC950).

Fluorescent indicator tube drive.

S E C O N DA RY board

47

STOP

I

Power supply (+5V).

48

Vss

—

I

System clock.

49

SIRCS

I

Sircs signal input.

I

System data.

50

POWER SW

I

Power switch input terminal.

PLL. DATA

I

PLL data input from TU001.

51

5.1ch LED

—

5.1ch LED drive.

12

S. CE (LC7288)

O

Chip enable output.

52

+5V

—

Power supply (+5V).

13

S. CE (LV100)

O

Chip enable output.

53

BASS BOOST

I

Bass boost LED drive.

REAR-R

I

Input for model select.

54

FUNC. MUTE

O

Line mute drive.

15

BRIDGE

I

Protector detect input.

55

SL MUTE

O

SL mute drive.

16

PROTECT

I

Protector detect input.

56

VERSION

I

Input for model select.

I

17

RESET

System reset terminal.

57

K14

I

Key in 4.

18

AUTO-STOP

I

Auto stop detect input.

58

K13

I

Key in 3.

19

STEREO-IN

I

Stereo detect input.

59

K12

I

Key in 2.

20

AVss

—

Ground.

60

K11

I

Key in 1.

21

SP-RY

O

Speaker relay drive.

61

SR MUTE

O

SR mute drive.

22

SURR-RY

O

Surround Relay.

62

S15

O

Key out 15.

23

POWER-RY

O

Power relay drive.

63

S14

O

Key out 14.

24

AVss

—

Ground.

64

S13

O

Key out 13.

25

SIGNAL

I

A/D signal input terminal.

65

S12

O

Key out 12.

26

A/D3

I

A/D3 key input terminal.

66

S11

O

Key out 11.

27

A/D2

I

A/D2 key input terminal.

67

S10

O

Key out 10.

28

A/D1

I

A/D1 key input terminal.

68

S9

O

Key out 9.

29

AVDD

—

Power supply (+5V).

69

S8

O

Key out 8.

30

AV. REF

—

Reference voltage (+5V).

70

S7

O

Key out 7.

31

GND

—

Ground.

71

VLOAD

—

Connect to –24V.

32

NC

—

Not used (Open).

72

S6

O

Key out 6.

33

Vss

—

Ground.

73

S5

O

Key out 5.

34

X1

I

System clock (4.19MHz).

74

S4

O

Key out 4.

35

X2

O

System clock (4.19MHz).

75

S3

O

Key out 3.

36

IC. MUTE

O

Mute drive output for µPD2581V (IC701).

76

S2

O

Key out 2.

37

Key out 1.

38

PROLOGIC

O

Plologic LED.

77

S1

O

SIMULATED

O

CINEMA STUDIO LED.

78

DIG10

O

39

HALL

O

HALL LED.

79

DIG9

O

40

T. MUTE

O

Tuner mute drive output.

80

DIG8

O

S T B Y board

P R IMA RY board

Ground.

11

14

CIRCUIT BOARDS LOCATION

Description

MIX board

S W board

MA IN board S P S W (A ) board

D IS P LAY board S P S W (B ) board K E Y board

     Fluorescent indicator tube drive.           

VO LU ME board V R -TO N E board

Fluorescent indicator tube drive.

Fluorescent indicator tube drive.

!¡ !£

!™

!º 9 8 7

1 WO O FE R 2 AC O U T LE T (E X C E P T U K ) 3 AC power cord 4 F R O N T S P E A K E R S (A /B ) 5 S U R R O U N D S P E A K E R S (C E N T E R ) 6 S U R R O U N D S P E A K E R S (R E A R ) 7 V ID E O

6 5

4

3

8 T V /LD 9 TA P E /MD !º C D !¡ P H O N O !™ A N T E N N A (F M/A M) !£ S IG N A L G N D

—3—

—4—

—5—

—6—

SECTION 4 EXPLODED VIEWS Note: • -XX, -X mean standardized parts, so they may have some differences from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items.

• • •

SECTION 5 ELECTRICAL PARTS LIST

The mechanical parts with no reference number in the exploded views are not supplied. Hardware (#mark) list is given in the last of this parts list. Abbreviation G : German EE : East European

4-2. T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.

CHASSIS SECTION pB : S W (A ) board pC : S W (B ) board

•

T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.

• •

FRONT PANEL SECTION

Abbreviations G : German EE : East European •

pA : V O LU ME board

7

8

8

Part No.

*

A-4392-962-A DISPLAY BOARD, COMPLETE (DE415:AEP,UK,G) ************************ A-4392-971-A DISPLAY BOARD, COMPLETE (DE315:AEP,UK,G) ************************ A-4398-073-A DISPLAY BOARD, COMPLETE (DE415:EE) ************************ A-4398-075-A DISPLAY BOARD, COMPLETE (DE315:EE) ************************

* *

8

a

Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX, -X mean standardized parts, so they may have some difference from the original one. Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. CAPACITORS: uF: µF

Ref. No.

*

* *

DISPLAY Ref. No.

W hen indicating parts by reference number, please include the board name.

•

4-1.

DISPLAY

Note:

Description

Remarks

4-921-941-01 CUSHION (FL) 4-943-107-11 HOLDER (FL TUBE)

Ref. No.

Part No.

•

• •

RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable COILS uH: µH SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD... Description

KEY

Description

S211 S212 S213 S214 S215

1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11

SWITCH, KEY BOARD (PRESET TUNING–) SWITCH, KEY BOARD (PRESET TUNING+) SWITCH, KEY BOARD (FM MODE) SWITCH, KEY BOARD (FM) SWITCH, KEY BOARD (AM)

S216

1-554-937-11 SWITCH, KEY BOARD (MEMORY)

SW200

10 13

11

13

a

not supplied

C201 C202 C203 C204 C205

1-104-905-11 1-164-159-21 1-124-465-00 1-164-159-21 1-162-294-31

C206 C207

1-164-159-21 CERAMIC 1-126-096-11 ELECT

4

1-410-509-11 INDUCTOR

#1

18 S O N Y

0.22F 0.1uF 0.47uF 0.1uF 0.001uF 0.1uF 10uF

10%

5.5V 50V 50V 50V 50V

20%

50V 35V

20%

CNS201 1-569-327-11 SOCKET, CONNECTOR 27P CNS202 1-770-400-11 HOUSING, CONNECTOR (PC BOARD) 7P

17 3 pA

15

< DIODE >

14

(Including pA ) #1

#1

2

18 1

Ref. No.

CAPACITOR CERAMIC ELECT CERAMIC CERAMIC

#1

15

Part No.

Description

Ref. No.

Part No.

Description

1 2 3 3 4

4-980-639-01 X-4946-873-1 4-989-844-31 4-989-844-51 4-980-109-01

KNOB (R14) KNOB (R48) ASSY PANEL, FRONT (DE415) PANEL, FRONT (DE315) BUTTON (P-M)

Remarks

* 9 10 11 12 13

A-4398-075-A 1-773-252-11 1-769-908-11 1-765-314-11 4-951-620-01

DISPLAY BOARD, COMPLETE (DE315:EE) WIRE (FLAT TYPE) (27 CORE) WIRE (FLAT TYPE) (9 CORE) WIRE (FLAT TYPE) (7 CORE) SCREW (2.6X8), +BVTP

* 5 * 6 * 7 8 * 9

4-921-941-01 4-943-107-11 4-980-658-01 3-704-366-01 A-4392-962-A

CUSHION (FL) HOLDER (FL TUBE) CASE (413226) SCREW (CASE) (M3X8) DISPLAY BOARD, COMPLETE(DE415:AEP,UK,G)

* 14 15 16 * 17 18

A-4392-964-A 4-977-593-11 3-008-600-11 A-4392-966-A 4-977-358-11

VR-TONE BOARD, COMPLETE RING (DIA. 50), ORNAMENTAL EMBLEM (5-AR), SONY KEY BOARD, COMPLETE CUSHION (8X12.5)

* 9 * 9

A-4392-971-A DISPLAY BOARD, COMPLETE(DE315:AEP,UK,G) A-4398-073-A DISPLAY BOARD, COMPLETE (DE415:EE)

FL201

— 23 —

1-517-141-11 INDICATOR TUBE, FLUORESCENT

Remarks

Remarks

D201 D202 D203 D204 D211

8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85

DIODE DIODE DIODE DIODE DIODE

1S1585 1S1585 1S1585 1S1585 1S1585

D212 D213 D214 D221 D223

8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85

DIODE DIODE DIODE DIODE DIODE

1S1585 1S1585 1S1585 1S1585 (DE315:EE/DE415:EE) 1S1585

DIODE DIODE DIODE DIODE DIODE

1S1585 (DE415) 1S1585 (DE315) 1S1585 SEL6810A-TH12 (HALL) SEL6810A-TH12 (C.STUDIO)

Ref. No.

Part No.

Description

Ref. No.

Part No.

Description

* 51 52 * 54 * 55 * 56

A-4392-965-A 4-951-801-01 1-665-273-11 1-665-274-11 1-665-272-11

SW BOARD, COMPLETE BUTTON (S) PRIMARY BOARD SECONDARY BOARD STANDBY BOARD

61 62 63 64 * 65

1-773-252-11 X-4947-207-1 4-924-098-01 4-812-134-00 4-924-098-21

WIRE (FLAT TYPE) (27 CORE) FOOT ASSY (F50150S) HOLDER, PC BOARD RIVET (DIA.3.5), NYLON HOLDER, PC BOARD

D224 D225 D231 D235 D236

8-719-815-85 8-719-815-85 8-719-815-85 8-719-313-50 8-719-313-50

* * * * *

57 57 57 57 58

A-4392-970-A A-4392-972-A A-4398-074-A A-4398-076-A 3-703-244-21

MAIN BOARD, COMPLETE (DE415:AEP,UK,G) MAIN BOARD, COMPLETE (DE315:AEP,UK,G) MAIN BOARD, COMPLETE (DE415:EE) MAIN BOARD, COMPLETE (DE315:EE) BUSHING (2104), CORD

67 70 ! 71 ! 71 ! 72

4-956-370-12 3-905-609-01 1-751-520-11 1-769-744-11 1-770-019-11

BAND, PLUG FIXED (DE315:UK) SCREW (TRANSISTOR) CORD, POWER (DE315:UK) CORD, POWER (EXCEPT DE315:UK) ADAPTER CONVERSION PLUG 3P (DE415:UK)

D237

8-719-313-50 DIODE SEL6810A-TH12 (PRO LOGIC)

DTA124ES DTC124ES DTC124ES DTC124ES

A-4392-966-A KEY BOARD, COMPLETE ********************

3-905-609-01 SCREW (TRANSISTOR) 4-812-134-00 RIVET (DIA. 3.5), NYLON 7-685-872-09 SCREW +BVTT 3X8 (S)

Q201 Q202 Q203 Q231

8-729-900-63 8-729-900-36 8-729-900-36 8-729-900-36

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

R200 R201 R202 R203 R204

1-247-863-91 1-247-903-00 1-249-429-11 1-249-429-11 1-249-425-11

CARBON CARBON CARBON CARBON CARBON

22K 1M 10K 10K 4.7K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W F

R232 R233 R234 R235 R236

1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11

CARBON CARBON CARBON CARBON CARBON

330 470 680 1K 1.5K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W F 1/4W F 1/4W F

R205 R206 R207 R211 R212

1-249-441-11 1-249-429-11 1-249-429-11 1-247-863-91 1-247-863-91

CARBON CARBON CARBON CARBON CARBON

100K 10K 10K 22K 22K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R237 R238 R239 R240 R241

1-249-421-11 1-247-843-11 1-249-411-11 1-249-413-11 1-249-415-11

CARBON CARBON CARBON CARBON CARBON

2.2K 3.3K 330 470 680

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W F 1/4W F

R213 R214 R216 R221 R222

1-247-863-91 1-247-863-91 1-247-863-91 1-247-807-31 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

22K 22K 22K 100 100

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R242 R243 R244 R245 R246

1-249-417-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-411-11

CARBON CARBON CARBON CARBON CARBON

1K 1.5K 2.2K 3.3K 330

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W F 1/4W 1/4W

R223 R224 R225 R226 R227

1-247-807-31 1-247-807-31 1-247-807-31 1-249-441-11 1-249-441-11

CARBON CARBON CARBON CARBON CARBON

100 100 100 100K 100K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R247 R248 R249 R280 R281

1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-421-11

CARBON CARBON CARBON CARBON CARBON

470 680 1K 1.5K 2.2K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R228 R229 R230 R231 R270

1-249-412-11 1-249-410-11 1-249-410-11 1-249-427-11 1-247-807-31

CARBON CARBON CARBON CARBON CARBON

390 270 270 6.8K 100

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W F 1/4W F 1/4W

R282

1-247-843-11 CARBON

3.3K

5%

1/4W

R283 R284 R286

1-249-427-11 CARBON 1-249-427-11 CARBON 1-249-437-11 CARBON

6.8K 6.8K 47K

5% 5% 5%

1/4W F 1/4W F 1/4W

S201 S202 S203 S204 S205

1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11

SWITCH, KEY BOARD (CENTER LEVEL–) SWITCH, KEY BOARD (CENTER LEVEL+) SWITCH, KEY BOARD (REAR LEVEL–) SWITCH, KEY BOARD (REAR LEVEL+) SWITCH, KEY BOARD (CHARACTER)

S206 S207 S208 S209 S210

1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11

SWITCH, KEY BOARD (DISPLAY) SWITCH, KEY BOARD (EON) SWITCH, KEY BOARD (PTY) SWITCH, KEY BOARD (TUNING–) SWITCH, KEY BOARD (TUNING+)

< CONNECTOR > CNP205 1-779-366-11 CONNECTOR, BOARD TO BOARD 4P < RESISTOR >

Remarks

* 59 * 59 * 59 60

4-989-901-51 4-989-901-61 4-989-902-31 1-666-496-11

PANEL, BACK (DE315:UK) PANEL, BACK (DE315:AEP,G,EE) PANEL, BACK (DE415) MIX BOARD (DE415)

! CNJ903 1-526-794-11 OUTLET, AC (EXCEPT DE315:UK) ! T901 1-431-260-11 TRANSFORMER, POWER (DE315) ! T901 1-431-266-11 TRANSFORMER, POWER (DE415)

< SWITCH >

— 24 —

T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.

* *

*

Remarks

A-4392-970-A MAIN BOARD, COMPLETE (DE415:AEP,UK,G) ********************** A-4392-972-A MAIN BOARD, COMPLETE (DE315:AEP,UK,G) ********************** A-4398-074-A MAIN BOARD, COMPLETE (DE415:EE) ********************** A-4398-076-A MAIN BOARD, COMPLETE (DE315:EE) **********************

*

X201 1-577-101-11 VIBRATOR, CERAMIC 4.19MHz ************************************************************

10uH

< TRANSISTOR >

Description SWITCH, KEY BOARD (2) SWITCH, KEY BOARD (3) SWITCH, KEY BOARD (4) SWITCH, KEY BOARD (5) SWITCH, KEY BOARD (DIRECT)

< CAPACITOR >

< CONNECTOR >

12 16

*

< VIBRATOR >

< COIL > L401

Part No. 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11

S238 1-554-937-11 SWITCH, KEY BOARD (MODE) S239 1-554-937-11 SWITCH, KEY BOARD (CD) ************************************************************

1-771-054-11 SWITCH, PUSH (1 KEY) (POWER)

Remarks

Ref. No. S233 S234 S235 S236 S237

< CAPACITOR >

5 13 9

F L201

Remarks

< SWITCH >

< RESISTOR >

6

5

MAIN

Part No.

< FILTER > FL201

1-517-141-11 INDICATOR TUBE, FLUORESCENT

IC201 IC202 IC203

8-759-479-19 IC uPD78044FGF-064-3B9 8-759-962-08 IC BA6208 8-759-332-18 IC GP1U27XB (REMOTE SENSOR)

< IC >

— 25 —

< SWITCH > S217 S218 S219 S220 S221

1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11

SWITCH, KEY BOARD (SURROUND ON/OFF) SWITCH, KEY BOARD (SET UP) SWITCH, KEY BOARD (EFFECT/DELAY TIME) SWITCH, KEY BOARD (TV/DBS) SWITCH, KEY BOARD (TUNER)

S222 S223 S224 S225 S226

1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11

SWITCH, KEY BOARD (PHONO) SWITCH, KEY BOARD (VIDEO) SWITCH, KEY BOARD (6) SWITCH, KEY BOARD (7) SWITCH, KEY BOARD (8)

S227 S228 S229 S231 S232

1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11 1-554-937-11

SWITCH, KEY BOARD (9) SWITCH, KEY BOARD (0) SWITCH, KEY BOARD (SHIFT) SWITCH, KEY BOARD (TAPE/MD) SWITCH, KEY BOARD (1)

F F F F F

C3 C4 C5 C6 C7

1-162-286-21 1-126-961-11 1-162-306-11 1-162-291-31 1-102-527-11

CERAMIC ELECT CERAMIC CERAMIC CERAMIC

220PF 2.2uF 0.01uF 560PF 82PF

10% 20% 20% 10% 5%

50V 50V 16V 50V 50V

C8 C302 C303 C304 C305

1-102-852-91 1-126-934-11 1-130-494-11 1-137-367-11 1-130-494-11

CERAMIC ELECT MYLAR FILM MYLAR

47PF 220uF 0.082uF 0.0033uF 0.082uF

5% 20% 5% 5% 5%

50V 16V 50V 50V 50V

C306 C307 C308 C309 C310

1-126-959-11 1-126-964-11 1-126-964-11 1-162-291-31 1-126-962-11

ELECT ELECT ELECT CERAMIC ELECT

0.47uF 10uF 10uF 560PF 3.3uF

20% 20% 20% 10% 20%

50V 50V 50V 50V 50V

C311 C312 C313 C314 C316

1-126-961-11 1-126-934-11 1-126-934-11 1-136-165-00 1-124-252-00

ELECT ELECT ELECT FILM ELECT

2.2uF 220uF 220uF 0.1uF 0.33uF

20% 20% 20% 5% 20%

50V 16V 16V 50V 50V

C317 C318 C322 C323 C324

1-126-933-11 1-137-363-91 1-126-962-11 1-136-173-00 1-126-967-11

ELECT FILM ELECT FILM ELECT

100uF 680PF 3.3uF 0.47uF 47uF

20% 5% 20% 5% 20%

16V 50V 50V 50V 16V

C325 C326 C327 C328 C329

1-136-165-00 1-136-165-00 1-126-959-11 1-126-963-11 1-126-959-11

FILM FILM ELECT ELECT ELECT

0.1uF 0.1uF 0.47uF 4.7uF 0.47uF

5% 5% 20% 20% 20%

50V 50V 50V 50V 50V

C335 C336 C337 C338 C339

1-136-161-00 1-126-934-11 1-126-964-11 1-126-964-11 1-126-964-11

FILM ELECT ELECT ELECT ELECT

0.047uF 220uF 10uF 10uF 10uF

5% 20% 20% 20% 20%

50V 16V 50V 50V 50V

C340 C341 C342 C343 C344

1-126-964-11 1-126-934-11 1-126-962-11 1-126-962-11 1-136-165-00

ELECT ELECT ELECT ELECT FILM

10uF 220uF 3.3uF 3.3uF 0.1uF

20% 20% 20% 20% 5%

50V 16V 50V 50V 50V

— 26 —

MAIN Ref. No.

Part No.

Description

Part No.

Description

C345 C346 C347 C348 C349

1-136-165-00 1-126-959-11 1-126-963-11 1-126-959-11 1-126-963-11

FILM ELECT ELECT ELECT ELECT

0.1uF 0.47uF 4.7uF 0.47uF 4.7uF

5% 20% 20% 20% 20%

Remarks 50V 50V 50V 50V 50V

C721 C722 C740 C741 C742

1-126-923-11 1-126-964-11 1-128-562-11 1-128-562-11 1-126-925-11

ELECT ELECT ELECT ELECT ELECT

220uF 10uF 47uF 47uF 470uF

20% 20% 20% 20% 20%

10V 50V 100V 100V 10V

C350 C351 C352 C353 C354

1-124-250-11 1-126-962-11 1-124-250-11 1-164-159-21 1-164-159-21

ELECT ELECT ELECT CERAMIC CERAMIC

0.15uF 3.3uF 0.15uF 0.1uF 0.1uF

20% 20% 20%

50V 50V 50V 50V 50V

C743 C752 C753 C755 C760

1-126-925-11 1-162-282-31 1-126-933-11 1-102-233-00 1-126-967-11

ELECT CERAMIC ELECT CERAMIC ELECT

470uF 100PF 100uF 33PF 47uF

20% 10% 20% 10% 20%

10V 50V 10V 500V 16V

C355 C356 C357 C359 C360

1-164-159-21 1-164-159-21 1-164-159-21 1-126-963-11 1-126-963-11

CERAMIC CERAMIC CERAMIC ELECT ELECT

0.1uF 0.1uF 0.1uF 4.7uF 4.7uF

50V 50V 50V 50V 50V

C761 C770 C799 C801 C802

1-137-372-11 1-162-286-21 1-164-159-21 1-104-664-11 1-104-664-11

FILM CERAMIC CERAMIC ELECT ELECT

0.022uF 220PF 0.1uF 47uF 47uF

5% 10% 20% 20%

50V 50V 50V 25V 25V

C363 C365 C366 C401 C402

1-164-159-21 1-126-966-11 1-164-159-21 1-162-286-21 1-126-962-11

CERAMIC ELECT CERAMIC CERAMIC ELECT

0.1uF 33uF 0.1uF 220PF 3.3uF

50V 16V 50V 50V 50V

C803 C804 C805 C806 C807

1-128-506-11 1-128-506-11 1-130-781-00 1-130-781-00 1-104-664-11

ELECT ELECT FILM FILM ELECT

6800uF 6800uF 0.22uF 0.22uF 47uF

20% 20% 10% 10% 20%

50V 50V 100V 100V 25V

C403 C404 C405 C406 C407

1-126-966-11 1-162-282-31 1-137-459-11 1-164-159-21 1-137-365-11

ELECT CERAMIC FILM CERAMIC FILM

33uF 100PF 0.0056uF 0.1uF 0.0015uF

20% 10% 5%

16V 50V 100V 50V 50V

C808 C809 C810 C811 C812

1-104-664-11 1-126-960-11 1-126-960-11 1-126-942-61 1-126-942-61

ELECT ELECT ELECT ELECT ELECT

47uF 1uF 1uF 1000uF 1000uF

20% 20% 20% 20% 20%

25V 50V 50V 25V 25V

C408 C409 C410 C412 C413

1-162-294-31 1-126-962-11 1-164-159-21 1-162-291-31 1-164-159-21

CERAMIC ELECT CERAMIC CERAMIC CERAMIC

0.001uF 3.3uF 0.1uF 560PF 0.1uF

10% 20%

50V 50V 50V 50V 50V

C813 C814 C820 C821 C822

1-101-001-00 1-101-001-00 1-161-494-00 1-161-494-00 1-104-664-11

CERAMIC CERAMIC CERAMIC CERAMIC ELECT

0.001uF 0.001uF 0.022uF 0.022uF 47uF

20%

50V 50V 25V 25V 25V

C415 C416 C434 C435 C451

1-164-159-21 1-164-159-21 1-162-286-21 1-162-286-21 1-162-286-21

CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC

0.1uF 0.1uF 220PF 220PF 220PF

C823 C950 C951 C952 C953

1-104-664-11 1-126-767-11 1-164-097-11 1-126-960-11 1-124-464-11

ELECT ELECT CERAMIC ELECT ELECT

47uF 1000uF 0.022uF 1uF 0.22uF

20% 20%

10% 10% 10%

50V 50V 50V 50V 50V

C452 C453 C454 C455 C457

1-126-962-11 1-126-966-11 1-162-282-31 1-137-459-11 1-137-365-11

ELECT ELECT CERAMIC FILM FILM

3.3uF 33uF 100PF 0.0056uF 0.0015uF

20% 20% 10% 5% 5%

50V 16V 50V 100V 50V

C954 C955 CC01 CC02 CC03

1-126-096-11 1-164-159-21 1-162-282-31 1-162-282-31 1-162-282-31

ELECT CERAMIC CERAMIC CERAMIC CERAMIC

10uF 0.1uF 100PF 100PF 100PF

20% 10% 10% 10%

35V 50V 50V 50V 50V

C459 C460 C602 C603 C605

1-126-962-11 1-164-159-21 1-162-282-31 1-126-933-11 1-102-233-00

ELECT CERAMIC CERAMIC ELECT CERAMIC

3.3uF 0.1uF 100PF 100uF 33PF

20% 10% 20% 10%

50V 50V 50V 10V 500V

CC04 CC05 CC06 CC07 CC51

1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31

CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC

100PF 100PF 100PF 100PF 100PF

10% 10% 10% 10% 10%

50V 50V 50V 50V 50V

C610 C611 C620 C652 C653

1-126-967-11 1-137-372-11 1-162-286-21 1-162-282-31 1-126-933-11

ELECT FILM CERAMIC CERAMIC ELECT

47uF 0.022uF 220PF 100PF 100uF

20% 5% 10% 10% 20%

16V 50V 50V 50V 10V

CC52 CC53 CC54 CC55 CC56

1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31 1-162-282-31

CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC

100PF 100PF 100PF 100PF 100PF

10% 10% 10% 10% 10%

50V 50V 50V 50V 50V

C655 C660 C661 C670 C702

1-102-233-00 1-126-967-11 1-137-372-11 1-162-286-21 1-162-282-31

CERAMIC ELECT FILM CERAMIC CERAMIC

33PF 47uF 0.022uF 220PF 100PF

10% 20% 5% 10% 10%

500V 16V 50V 50V 50V

CC57

1-162-282-31 CERAMIC

100PF

10%

50V

C703 C705 C710 C711 C720

1-126-933-11 1-102-233-00 1-126-967-11 1-137-372-11 1-162-286-21

ELECT CERAMIC ELECT FILM CERAMIC

100uF 33PF 47uF 0.022uF 220PF

20% 10% 20% 5% 10%

10V 500V 16V 50V 50V

20% 20%

20% 10% 20%

5%

10%

Ref. No.

Remarks

20% 20%

< CONNECTOR > CNP702 CNP706 CNS204 CNS301 CNS701

1-750-388-11 1-764-477-11 1-569-327-11 1-568-442-11 1-568-439-11

PIN, CONNECTOR 5P PIN, CONNECTOR (PC BOARD) 8P SOCKET, CONNECTOR 27P SOCKET, CONNECTOR 9P SOCKET, CONNECTOR 7P

CNS802 1-770-480-11 SOCKET, CONNECTOR PIN 4P

— 27 —

25V 16V 50V 50V 50V

MAIN Ref. No.

Part No.

Description

Remarks

Ref. No.

Part No.

< DIODE >

Description

Remarks

< TRANSISTOR >

D610 D710 D721 D722 D723

8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85 8-719-815-85

DIODE DIODE DIODE DIODE DIODE

1S1585 1S1585 1S1585 1S1585 1S1585

Q303 Q304 Q307 Q308 Q601

8-729-922-37 8-729-922-37 8-729-922-37 8-729-922-37 8-729-119-76

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

D724 D725 D801 D802 D804

8-719-815-85 8-719-815-85 8-719-002-33 8-719-302-38 8-719-010-38

DIODE DIODE DIODE DIODE DIODE

1S1585 1S1585 UZL-24L RBV-602-01 UZ-5.1BSB

Q602 Q603 Q604 Q610 Q620

8-729-141-30 8-749-010-25 8-749-010-26 8-729-119-78 8-729-140-82

TRANSISTOR 2SC3623A-LK IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR 2SC403SP-51 TRANSISTOR 2SA988-PAFAEA

D810 D811 D812 D813 D814

8-719-200-82 8-719-200-82 8-719-200-82 8-719-200-82 8-719-815-85

DIODE DIODE DIODE DIODE DIODE

11ES2 11ES2 11ES2 11ES2 1S1585

Q651 Q652 Q653 Q654 Q670

8-729-119-76 8-729-141-30 8-749-010-25 8-749-010-26 8-729-140-82

TRANSISTOR 2SA1175-HFE TRANSISTOR 2SC3623A-LK IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR 2SA988-PAFAEA

D815 D817 D818 D820 D821

8-719-815-85 8-719-001-31 8-719-815-85 8-719-200-82 8-719-200-82

DIODE DIODE DIODE DIODE DIODE

1S1585 UZL-9H3-TA 1S1585 11ES2 11ES2

Q701 Q702 Q703 Q704 Q710

8-729-119-76 8-729-141-30 8-749-010-25 8-749-010-26 8-729-119-78

TRANSISTOR 2SA1175-HFE TRANSISTOR 2SC3623A-LK IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR 2SC403SP-51

D822 D823 D901

8-719-200-82 DIODE 11ES2 8-719-200-82 DIODE 11ES2 8-719-815-85 DIODE 1S1585

Q720 Q721 Q722 Q723 Q751

8-729-140-82 8-729-140-82 8-729-140-84 8-729-119-78 8-729-119-76

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

Q752 Q753 Q754 Q770 Q801

8-729-141-30 8-749-010-25 8-749-010-26 8-729-140-82 8-729-140-97

TRANSISTOR 2SC3623A-LK IC MN2488-OPY-M IC MP1620-OPY-M TRANSISTOR 2SA988-PAFAEA TRANSISTOR 2SB734-34

Q802 Q808 Q809 Q951

8-729-119-78 8-729-180-92 8-729-119-78 8-729-030-18

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

< TERMINAL > * G200 * G201 * G202

1-537-738-21 TERMINAL, EARTH 1-537-738-21 TERMINAL, EARTH 1-537-738-21 TERMINAL, EARTH < IC >

IC1 IC300 IC301 IC302 IC401

8-759-450-86 8-759-442-97 8-759-442-96 8-759-636-74 8-759-805-14

IC IC IC IC IC

BU1922 LV1016 LA2786 M5218AP-22 LC7822

IC402 IC701 IC702 IC801 IC802

8-759-636-74 8-759-326-52 8-759-326-52 8-759-231-58 8-759-604-45

IC IC IC IC IC

M5218AP-22 uPC2581V uPC2581V TA7812S M5F79M12

IC950

8-759-333-83 IC NJM2103D

2SD2144S 2SD2144S 2SD2144S 2SD2144S 2SA1175-HFE

2SA988-PAFAEA 2SA988-PAFAEA 2SC1841-PAFAEA 2SC403SP-51 2SA1175-HFE

2SC403SP-51 2SD809-K 2SC403SP-51 2SD2525

< RESISTOR >

< JACK > J401 J402 J403

1-770-614-11 JACK, PIN 4P (PHONO/CD) 1-770-015-11 JACK, PIN 6P (TAPE/MD,TV DBS AUDIO IN) 1-770-614-11 JACK, PIN 4P (VIDEO) < COIL >

L1 L301 L302 L601 L651

1-410-521-11 1-410-509-11 1-410-509-11 1-420-872-00 1-420-872-00

INDUCTOR 100uH INDUCTOR 10uH INDUCTOR 10uH COIL, AIR-CORE COIL, AIR-CORE

L701 L751

1-420-872-00 COIL, AIR-CORE 1-420-872-00 COIL, AIR-CORE

R5 R6 R7 R300 R301

1-249-421-11 1-247-807-31 1-247-807-31 1-247-903-00 1-249-421-11

CARBON CARBON CARBON CARBON CARBON

2.2K 100 100 1M 2.2K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W F

R302 R303 R304 R306 R307

1-249-421-11 1-249-439-11 1-249-441-11 1-249-436-11 1-247-862-11

CARBON CARBON CARBON CARBON CARBON

2.2K 68K 100K 39K 20K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W

R308 R309 R352 R353 R354

1-249-421-11 1-249-421-11 1-249-441-11 1-249-425-11 1-249-425-11

CARBON CARBON CARBON CARBON CARBON

2.2K 2.2K 100K 4.7K 4.7K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R355 R356 R357 R358 R359

1-249-425-11 1-249-425-11 1-249-441-11 1-249-441-11 1-249-425-11

CARBON CARBON CARBON CARBON CARBON

4.7K 4.7K 100K 100K 4.7K

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W 1/4W 1/4W F

— 28 —

F F F F

MAIN Ref. No.

Part No.

Description

Remarks

Ref. No.

Part No.

Description

R360 R361 R362 R363 R401

1-247-843-11 1-249-429-11 1-249-429-11 1-249-411-11 1-249-411-11

CARBON CARBON CARBON CARBON CARBON

3.3K 10K 10K 330 330

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R620 R621 ! R622 R623 R630

1-249-419-11 1-249-426-11 1-249-403-11 1-249-437-11 1-249-426-11

CARBON CARBON CARBON CARBON CARBON

1.5K 5.6K 68 47K 5.6K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W F 1/4W 1/4W

R402 R403 R404 R405 R406

1-249-421-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11

CARBON CARBON CARBON CARBON CARBON

2.2K 1K 1K 1K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R631

1-247-887-00 CARBON

220K

5%

R632 R651 R652 R653

1-249-426-11 1-249-417-11 1-249-439-11 1-249-414-11

CARBON CARBON CARBON CARBON

5.6K 1K 68K 560

5% 5% 5% 5%

1/4W (DE415) 1/4W 1/4W F 1/4W 1/4W F

R407 R408 R409 R410 R411

1-249-417-11 1-249-429-11 1-249-437-11 1-247-897-11 1-249-416-11

CARBON CARBON CARBON CARBON CARBON

1K 10K 47K 560K 820

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W F

R654 R655 R660 R661 R663

1-249-439-11 1-249-441-11 1-249-421-11 1-249-437-11 1-249-414-11

CARBON CARBON CARBON CARBON CARBON

68K 100K 2.2K 47K 560

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W 1/4W F

R412 R413 R414 R415 R416

1-247-897-11 1-249-437-11 1-249-425-11 1-249-417-11 1-249-417-11

CARBON CARBON CARBON CARBON CARBON

560K 47K 4.7K 1K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W F 1/4W F

! R664 ! R665 ! R666 ! R667 R668

1-249-409-11 1-249-409-11 1-233-352-41 1-249-393-11 1-249-389-11

CARBON 220 5% CARBON 220 5% ENCAPSULATED COMPONENT CARBON 10 5% CARBON 4.7 5%

1/4W F 1/4W F

R417 R420 R435 R442 R443

1-247-897-11 1-249-441-11 1-249-418-11 1-249-418-11 1-249-418-11

CARBON CARBON CARBON CARBON CARBON

560K 100K 1.2K 1.2K 1.2K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W F 1/4W F

R670 R671 R672 R673 R701

1-249-419-11 1-249-426-11 1-249-431-11 1-249-437-11 1-249-417-11

CARBON CARBON CARBON CARBON CARBON

1.5K 5.6K 15K 47K 1K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W F

R447 R448 R449 R451 R452

1-249-416-11 1-249-429-11 1-247-863-91 1-249-411-11 1-249-421-11

CARBON CARBON CARBON CARBON CARBON

820 10K 22K 330 2.2K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W F

R702 R703 R704 R705 R710

1-249-439-11 1-249-414-11 1-249-439-11 1-249-441-11 1-249-421-11

CARBON CARBON CARBON CARBON CARBON

68K 560 68K 100K 2.2K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W 1/4W 1/4W F

R453 R454 R455 R456 R457

1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11

CARBON CARBON CARBON CARBON CARBON

1K 1K 1K 1K 1K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R711 R713 ! R714 ! R715 ! R716

1-249-437-11 1-249-414-11 1-249-409-11 1-249-409-11 1-233-352-41

CARBON 47K 5% CARBON 560 5% CARBON 220 5% CARBON 220 5% ENCAPSULATED COMPONENT

1/4W 1/4W F 1/4W F 1/4W F

R458 R459 R460 R461 R462

1-249-429-11 1-249-437-11 1-247-897-11 1-249-416-11 1-247-897-11

CARBON CARBON CARBON CARBON CARBON

10K 47K 560K 820 560K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W F 1/4W

! R717 R718 ! R719 R720 R721

1-249-393-11 1-249-389-11 1-249-405-11 1-249-419-11 1-249-426-11

CARBON CARBON CARBON CARBON CARBON

10 4.7 100 1.5K 5.6K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R463 R465 R466 R467 R470

1-249-437-11 1-249-417-11 1-249-417-11 1-247-897-11 1-249-441-11

CARBON CARBON CARBON CARBON CARBON

47K 1K 1K 560K 100K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W F 1/4W 1/4W

! R722 R723 R724 R725 R726

1-249-403-11 1-249-437-11 1-249-425-11 1-249-429-11 1-249-417-11

CARBON CARBON CARBON CARBON CARBON

68 47K 4.7K 10K 1K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W F 1/4W 1/4W F

R473 R601 R602 R603 R604

1-249-437-11 1-249-417-11 1-249-439-11 1-249-414-11 1-249-439-11

CARBON CARBON CARBON CARBON CARBON

47K 1K 68K 560 68K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W 1/4W F 1/4W

R727 R730 R731

1-249-427-11 CARBON 1-249-429-11 CARBON 1-247-887-00 CARBON

6.8K 10K 220K

5% 5% 5%

R734

1-249-429-11 CARBON

10K

5%

R605 R610 R611 R613 ! R614

1-249-441-11 1-249-421-11 1-249-437-11 1-249-414-11 1-249-409-11

CARBON CARBON CARBON CARBON CARBON

100K 2.2K 47K 560 220

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W 1/4W F 1/4W F

! R740

1-249-393-11 CARBON

10

5%

1/4W F 1/4W 1/4W (DE415) 1/4W (DE415) 1/4W F

! R615 ! R616 ! R617 R618 ! R619

1-249-409-11 1-233-352-41 1-249-393-11 1-249-389-11 1-249-405-11

CARBON 220 5% ENCAPSULATED COMPONENT CARBON 10 5% CARBON 4.7 5% CARBON 100 5%

1/4W F

! R741 R742 R743 R751 R752

1-249-393-11 1-249-425-11 1-249-425-11 1-249-417-11 1-249-439-11

10 4.7K 4.7K 1K 68K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

F F F F F

F F F F F

CARBON CARBON CARBON CARBON CARBON

Remarks

1/4W F 1/4W F

1/4W F 1/4W F 1/4W F

— 29 —

T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.

F F F F

F F F F

MAIN Ref. No.

MIX

PRIMARY

SECONDARY

STBY

Part No.

Description

Remarks

Ref. No.

Part No.

R753 R754 R755 R760 R761

1-249-414-11 1-249-439-11 1-249-441-11 1-249-421-11 1-249-437-11

CARBON CARBON CARBON CARBON CARBON

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W F 1/4W

*

1-666-496-11 MIX BOARD (DE415) **********

R763 ! R764 ! R765 ! R766 ! R767

1-249-414-11 1-249-409-11 1-249-409-11 1-233-352-41 1-249-393-11

CARBON 560 5% CARBON 220 5% CARBON 220 5% ENCAPSULATED COMPONENT CARBON 10 5%

1/4W F 1/4W F 1/4W F

R768 R770 R771 R772 R773

1-249-389-11 1-249-419-11 1-249-426-11 1-249-431-11 1-249-437-11

CARBON CARBON CARBON CARBON CARBON

4.7 1.5K 5.6K 15K 47K

5% 5% 5% 5% 5%

1/4W F 1/4W F 1/4W 1/4W 1/4W

R781

1-247-887-00 CARBON

220K

5%

! R803 R804 R821 R822

1-249-389-11 1-249-421-11 1-249-437-11 1-249-425-11

CARBON CARBON CARBON CARBON

4.7 2.2K 47K 4.7K

5% 5% 5% 5%

1/4W (DE415) 1/4W F 1/4W F 1/4W 1/4W F

R823 R824 R825 ! R830 ! R831

1-249-437-11 1-249-425-11 1-249-407-11 1-249-405-11 1-249-403-11

CARBON CARBON CARBON CARBON CARBON

47K 4.7K 150 100 68

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W 1/4W

R950 R951 R952 R953 R954

1-249-421-11 1-249-429-11 1-247-843-11 1-247-863-91 1-249-439-11

CARBON CARBON CARBON CARBON CARBON

2.2K 10K 3.3K 22K 68K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W

R955 R956 R957 R958 R960

1-249-429-11 1-247-843-11 1-249-417-11 1-249-401-11 1-249-429-11

CARBON CARBON CARBON CARBON CARBON

10K 3.3K 1K 47 10K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W F 1/4W

560 68K 100K 2.2K 47K

Description

Remarks

< CONNECTOR > CNS253 1-691-765-11 PLUG (MICRO CONNECTOR) 3P (DE415)

1/4W F

< JACK > J253 1-774-843-11 JACK, PIN 1P (MIX)(DE415) ************************************************************ *

1-665-273-11 PRIMARY BOARD ************** 1-533-233-21 HOLDER, FUSE < FUSE >

*

1-665-274-11 SECONDARY BOARD ***************** < CONNECTOR >

F F F F

CNP801 1-764-480-11 PIN, CONNECTOR (PC BOARD) 11P < RESISTOR > ! R810 1-249-381-11 CARBON 1 5% 1/4W F ! R811 1-249-381-11 CARBON 1 5% 1/4W F ************************************************************ *

1-665-272-11 STBY BOARD *********** 1-533-233-11 HOLDER, FUSE < CONNECTOR > CNP802 1-779-495-11 PLUG, CONNECTOR PIN 4P CNP901 1-564-321-00 PIN, CONNECTOR 2P CNP903 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P (AEP,G,EE)

< RELAY > RY601 RY701 RY801

! F901 1-532-259-00 FUSE TIME LAG 1.6A ************************************************************

1-515-921-11 RELAY (12V) 1-515-921-11 RELAY (12V) 1-755-013-11 RELAY

< DIODE > D816

8-719-815-85 DIODE 1S1585

< TERMINAL > < FUSE > TM1 TM601 TM701

1-694-266-11 TERMINAL BOARD, ANT (ANTENNA) 1-537-510-11 TERMINAL BOARD (SPEAKER) (6P) (SURROUND SPEAKER) 1-537-376-11 TERMINAL BOARD (SPEAKER) (FRONT SPEAKER)

1-532-286-00 FUSE TIME LAG 2.5A (AEP,G,EE) < RELAY >

! RY901

< TUNER > TU001 TU001

! F902

1-233-594-12 ENCAPSULATED COMPONENT (AEP,UK,G) 1-233-595-11 ENCAPSULATED COMPONENT (EE)

1-515-720-11 RELAY < TRANSFORMER >

! T902 1-450-358-11 TRANSFORMER, POWER ************************************************************

< VIBRATOR > X1 1-579-900-21 VIBRATOR, CRYSTAL 4.33MHz X301 1-579-952-21 VIBRATOR, CERAMIC 8MHz ************************************************************

— 30 —

T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.

SW Ref. No.

Part No.

*

A-4392-965-A SW BOARD, COMPLETE ******************* SW (A) BOARD ************ SW (B) BOARD ************

Description

SW (A)

Remarks

Ref. No.

SW (B) Part No.

VOLUME

VR-TONE

Description

Remarks

< CONNECTOR > CNP202 1-770-391-11 PIN, CONNECTOR (PC BOARD) 7P CNS402 1-568-439-11 SOCKET, CONNECTOR 7P CNS403 1-568-442-11 SOCKET, CONNECTOR 9P < DIODE >

< CONNECTOR > CNP703 CNP704 CNS205 CNS702

1-764-474-11 1-764-473-11 1-770-397-11 1-770-378-11

D238 D421

PIN, CONNECTOR (PC BOARD) 5P PIN, CONNECTOR (PC BOARD) 3P HOUSING, CONNECTOR(PC BOARD)4P CONNECTOR, BOARD TO BOARD 5P

8-719-313-50 DIODE SEL6810A-TH12 (BASS BOOST) 8-719-815-85 DIODE 1S1585 < IC >

IC404

8-759-636-74 IC M5218AP-22

< JACK > < TRANSISTOR > J741

1-750-733-11 JACK (LARGE TYPE) (PHONES) < RESISTOR >

R741 R742 R791 R792

1-260-100-11 1-260-100-11 1-260-100-11 1-260-100-11

CARBON CARBON CARBON CARBON

1.2K 1.2K 1.2K 1.2K

5% 5% 5% 5%

1/2W 1/2W 1/2W 1/2W

< SWITCH > S701 1-762-319-11 SWITCH, PUSH (2 KEY) (SPEAKERS) ************************************************************ *

A-4392-964-A VR-TONE BOARD, COMPLETE ************************ VOLUME BOARD **************

Q401 Q402 Q451 Q452

8-729-202-67 8-729-141-30 8-729-202-67 8-729-141-30

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SK246-GR3 2SC3623A-LK 2SK246-GR3 2SC3623A-LK

< RESISTOR > R420 R421 R422 R423 R424

1-249-415-11 1-249-430-11 1-249-422-11 1-247-903-00 1-247-903-00

CARBON CARBON CARBON CARBON CARBON

680 12K 2.7K 1M 1M

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W F 1/4W 1/4W

R425 R426 R427 R430 R431

1-249-429-11 1-249-439-11 1-249-417-11 1-249-437-11 1-247-843-11

CARBON CARBON CARBON CARBON CARBON

10K 68K 1K 47K 3.3K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W F 1/4W 1/4W

R432 R433 R434 R438 R441

1-247-883-00 1-249-427-11 1-249-413-11 1-249-441-11 1-249-441-11

CARBON CARBON CARBON CARBON CARBON

150K 6.8K 470 100K 100K

5% 5% 5% 5% 5%

1/4W 1/4W F 1/4W F 1/4W 1/4W

R444 R464 R469 R470 R471

1-247-903-00 1-247-903-00 1-247-903-00 1-249-415-11 1-249-430-11

CARBON CARBON CARBON CARBON CARBON

1M 1M 1M 680 12K

5% 5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W F 1/4W

R472 R473 R474 R475 R476

1-249-422-11 1-247-903-00 1-247-903-00 1-249-429-11 1-249-439-11

CARBON CARBON CARBON CARBON CARBON

2.7K 1M 1M 10K 68K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W

R477 R480 R481 R482 R483

1-249-417-11 1-249-437-11 1-247-843-11 1-247-883-00 1-249-427-11

CARBON CARBON CARBON CARBON CARBON

1K 47K 3.3K 150K 6.8K

5% 5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W 1/4W F

R484 R491 R492 R494

1-249-413-11 1-249-441-11 1-247-903-00 1-247-903-00

CARBON CARBON CARBON CARBON

470 100K 1M 1M

5% 5% 5% 5%

1/4W F 1/4W 1/4W 1/4W

< CAPACITOR > C420 C421 C422 C423 C424

1-162-207-31 1-137-440-11 1-124-463-00 1-137-368-11 1-137-372-11

CERAMIC FILM ELECT FILM FILM

22PF 0.018uF 0.1uF 0.0047uF 0.022uF

5% 5% 20% 5% 5%

50V 50V 50V 50V 50V

C425 C426 C427 C428 C429

1-126-096-11 1-126-096-11 1-124-252-00 1-130-489-00 1-102-973-00

ELECT ELECT ELECT MYLAR CERAMIC

10uF 10uF 0.33uF 0.033uF 100PF

20% 20% 20% 5% 5%

35V 35V 50V 50V 50V

C430 C431 C432 C433 C470

1-126-301-11 1-126-301-11 1-126-096-11 1-126-096-11 1-162-207-31

ELECT ELECT ELECT ELECT CERAMIC

1uF 1uF 10uF 10uF 22PF

20% 20% 20% 20% 5%

50V 50V 35V 35V 50V

C471 C472 C473 C474 C475

1-137-440-11 1-124-463-00 1-137-368-11 1-137-372-11 1-126-096-11

FILM ELECT FILM FILM ELECT

0.018uF 0.1uF 0.0047uF 0.022uF 10uF

5% 20% 5% 5% 20%

50V 50V 50V 50V 35V

C476 C477 C478 C479 C492

1-126-096-11 1-124-252-00 1-130-489-00 1-102-973-00 1-124-464-11

ELECT ELECT MYLAR CERAMIC ELECT

10uF 0.33uF 0.033uF 100PF 0.22uF

20% 20% 5% 5% 20%

35V 50V 50V 50V 50V

C601 C651 C701 C751

1-126-163-11 1-126-163-11 1-126-163-11 1-126-163-11

ELECT ELECT ELECT ELECT

4.7uF 4.7uF 4.7uF 4.7uF

20% 20% 20% 20%

50V 50V 50V 50V

< VARIABLE RESISTOR > RV404 RV421 RV422 RV423

— 31 —

1-225-229-11 RES, VAR, CARBON 100KX4 (MASTER VOLUME) 1-223-362-11 RES, VAR, CARBON 100K/100K (BASS) 1-223-363-11 RES, VAR, CARBON 125K/125K (TREBLE) 1-225-447-11 RES, VAR, CARBON 100K/100K (BALANCE)

STR-DE315/DE415 VOLUME Ref. No.

VR-TONE

Part No.

Description

Remarks

Ref. No.

Part No.

< SWITCH >

1-475-042-11 1-475-136-21 1-475-137-11 1-501-374-11 1-501-594-11

MISCELLANEOUS ************** 1-769-908-11 1-765-314-11 1-773-252-11 1-751-520-11 1-769-744-11

Remarks

ACCESSORIES & PACKING MATERIALS *******************************

S240 1-554-937-11 SWITCH, KEY BOARD (BASS BOOST) ************************************************************

11 12 61 ! 71 ! 71

Description

WIRE (FLAT TYPE) (9 CORE) WIRE (FLAT TYPE) (7 CORE) WIRE (FLAT TYPE) (27 CORE) CORD, POWER (UK) CORD, POWER (AEP,G,EE)

! CNJ903 1-526-794-11 OUTLET, AC (AEP,G,EE) ! T901 1-431-260-11 TRANSFORMER, POWER (DE315) ! T901 1-431-266-11 TRANSFORMER, POWER (DE415) ************************************************************

ADAPTOR (21PIN D. SUB) REMOTE COMMANDER (RM-U301) (DE315) REMOTE COMMANDER (RM-P301) (DE415) ANTENNA, LOOP ANTENNA (FM)

3-859-657-11 MANUAL, INSTRUCTION (ENGLISH/FRENCH/GERMAN/DUTCH/ITALIAN)(AEP,UK,G) 3-859-657-41 MANUAL, INSTRUCTION (SPANISH/SWEDISH/FRENCH/DANISH/PORTUGUESE)(AEP) 3-859-657-51 MANUAL, INSTRUCTION (ENGLISH/RUSSIAN/POLISH)(EE) 4-981-643-01 COVER, BATTERY (for RM-P301/U301) ************************************************************ ************** HARDWARE LIST ************** #1 #2 #3 #4

7-685-646-79 7-685-881-09 7-685-872-09 7-658-646-71

SCREW +BVTP 3X8 TYPE2 IT-3 SCREW +BVTT 4X8 (S) SCREW +BVTT 3X8 (S) SCREW +BTP 3X8

T he components identified by mark ! or dotted line with mark ! are critical for safety. R eplace only with part number specified.

Sony Corporation 9-920-941-11

Home A&V Products Company

— 32 —

97H 167554-1 P rinted in H ungary © 1997.8 Published by General Engineering Dept. (Shibaura)